We may earn a referral commission from some links on this page. It doesn't change your price or our recommendations.
Thruster specs
Sideshift SD230-D: specs, price and the boats it fits
The SD230-D is made for twin sterndrive boats of 30 to 40 ft: two SD230 thrusters in one kit, one bolted to each drive. Nothing goes through the hull, and the push follows the wheel because each unit turns with its drive. Sideshift brought out its multi-engine kits in 2023.
Two single SD230 kits would come to $8,990. This kit is $4,995, which saves you $3,995. Sideshift lists one controller and one joystick for the pair, so there’s less to wire.
Batteries are the extra: two starting batteries wired together, heavy cable and a charger, about $620 to $707 more. Sideshift lists two different power draws for this kit on its own pages, so have your installer size the cable for the higher one.
Trim both drives on plane so the units ride just clear of the water. The shaft seals are the wear item, lasting seven or eight years in owner reports on Sideshift’s older units. Give it 3 to 5 seconds at a time and never more than 20 to 30. A replacement motor is $995 per unit, and the warranty covers parts for two years.
Fitting it yourself? The installer section has every spec, and the Sideshift thruster review sets this model against the rest of the Sideshift range.
Where this summary comes from (9 sources, read 11 October 2026)
- Sideshift product page
- Great Lakes Scuttlebutt Launch Issue 2023: ST230-Dual for twin and triple motors
- Sideshift monohull installation manual, Rev 3.1 (Nov 2025)
- Sideshift FAQ
- Sideshift store: replacement motor kits
- Lakeland Boating, 10 Aug 2020: first stern thruster for outboard and sterndrive boats
- US patent 10,953,974: stern-mounted lateral marine thruster (Sideshift, 2021)
- Trawler Forum owner thread: Sideshift thruster (seal and receiver reports)
- Carver Yacht Owners thread: bow thruster (seal and weed reports)
Key facts
- DIY level 4 of 5 You fit it, electrician connects
- Thrust Not published Our sizing works from the motor's rating
- Boat length 30 to 40 ft Sideshift's own range
- Price $4,995 full kit, sideshift.com, 28 August 2026
- Fitted by a yard $6,903 to $9,314 Our estimate at 27 to 44 ft, unit and job
- Voltage 12 V As sold
- Mounts External Fixed mount, stern
- To fit it Afloat The maker says it goes on in the water
- Run limit Bursts of 3 to 5 seconds Never more than 20 to 30 seconds at a time
Every figure here is the maker’s or a dealer’s, except the fitted cost, which is our estimate. The full spec sheet is further down.
How much of the install is yours
DIY levels
- Level 5: Owner install. No yard, no electrician.
- Level 4: You fit it, electrician connects. You mount and wire it; a marine electrician makes the final connections.
- Level 3: Split with the yard. The yard does the below-waterline part; you do the wiring.
- Level 2: Wiring prep only. The yard fits the unit and does the hull work; you do the wiring prep.
- Level 1: Yard job. A qualified professional does all of it.
You Yard Electrician. The bar is labor hours; a haul-out is a note.
How we rate DIYYou: 6 to 8 h Yard: none Electrician: 2 to 4 h No haul-out.
- Mount the thruster; fit the battery, controller and joystick; run the cables You 6 to 8 h Sideshift’s own figure: 6 to 8 hours per thruster, depending on the wire runs. Every mount and connection is above the waterline. Source.
- Final connections at the battery and the motor, load test Electrician 2 to 4 h Our estimate. Nobody publishes a time for the final connections and test on their own.
Your part needs:Drilling above the waterlineHeavy battery cableCrimping big lugs
A qualified marine electrician should make the final connections and test them before first use. Hours are labor only.
Is it right for your boat?
Sideshift prints no thrust, so our sizing uses an estimate from the motor’s rating. That estimate can say a boat is too big for it. It cannot promise a fit. The maker gives one range for every boat.
The table below tries the Sideshift SD230-D Sterndrive Stern Thruster on each kind of boat, at every length that kind of boat is built in. The wind is 15 knots and the rules are the finder’s own. A length counts as a fit when the unit gives the thrust that boat needs where it mounts and the maker lists it for that length.
A boat up to 10 percent past the maker’s range still counts here, as it does in the finder. So the table runs down to 27 ft and up to 44 ft, just past Sideshift’s own range (30 to 40 ft).
| Boat | Lengths it fits, on our estimate |
|---|---|
| Pontoon & tritoon | Not listed. Its maker sells it for another kind of boat. |
| Sailboat | Not listed. Its maker sells it for another kind of boat. |
| Houseboat | Not listed. Its maker sells it for another kind of boat. |
| Catamaran | Not listed. An external unit bolts to the side of a single hull at the bow or to its transom, and a cat has two narrow hulls with a bridgedeck between them, so there is nowhere forward to hang one. |
| Trawler | Not listed. Its maker sells it for another kind of boat. |
| Motor yacht | Not listed. Its maker sells it for another kind of boat. |
| Bass & flats | Not listed. Its maker sells it for another kind of boat. |
| Wake & ski boats | Not listed. Its maker sells it for another kind of boat. |
| Express cruiser | 27 to 44 ft |
| Center console | Not listed. Its maker sells it for another kind of boat. |
It is sized for one kind of boat here. For your own boat, the finder gives an answer that also counts your drive and who does the fitting. The compare page sets this unit beside others.
What it costs fitted
These totals are our estimate of a yard job: the unit’s price, plus a yard’s hours at $160 to $180 an hour, plus the batteries, cable and charger, plus the other parts the box does not hold. The hours come from what owners and yards report. Your own yard will have its own opinion. The cost page builds the same figures line by line.
- The unit$4,995
- Yard labor$1,280 to $3,6008 to 20 hours
- Batteries, cable, charger$620 to $707
- Other parts$8 to $12
- Total, 27 to 44 ft$6,903 to $9,314Our estimate
The Sideshift SD230-D Sterndrive Stern Thruster fitted by a yard. It comes to the same at every length it is sized for. Our estimate.
How the batteries, cable and charger add up. We price a battery bank close to the thruster, as the makers recommend, with 10 to 20 ft of cable out and back: red for the positive, black for the negative, cut to length. The low end is the cheapest battery that meets the figure and the shorter run; the high end is a sealed (AGM) battery and the longer run. The charger is a NOCO GEN5X2 two-bank shore charger.
Batteries and lugs are priced at Fisheries Supply and the cable and charger at Defender, read 12 October 2026.
- At 12 V: one 12 V battery, at least 850 CCA (Sideshift’s minimum), $360 for the battery; Sideshift’s cable table gives 2/0 AWG: $114 to $201 for the red and black cable and the lugs; a GEN5X2 charger, $146.
Fitting it yourself. Tell the finder you will fit a Sideshift yourself and it takes the yard’s labor off. With that off, the total is $5,623 to $5,714. That is the unit plus the batteries, cable and other parts, which you buy whoever does the fitting.
The sizing and the costs on this page are estimates, for guidance only and without warranty. They are no quote, and nobody has inspected your boat. Check them against the maker’s manual and your yard before you rely on them. Terms of use.
What else you buy
What follows comes from Sideshift’s Monohull installation manual Rev 3.1, November 2025, read 30 September 2026.
- In the box
- The thruster, the motor controller, the wireless joystick and its receiver, a wireless key fob, the wiring harness and mounting hardware, the fuse in a holder with a digital voltage display, and a battery switch. Sideshift lists these on each product page. The manual adds the crimper, anti-seize, Loctite, Sikaflex and heat shrink.
- Bought separately
- The batteries, the 1/0 or 2/0 battery cable and the charger. The joystick is wireless: no wire runs from it to the thruster. It still needs 12 V at the helm for its own power, so plan a small feed there.
- Charging
- The thruster gets a bank of its own: cranking type, 850 cold cranking amps per battery, within 10 ft of the controller. You buy the charger too, either a shore charger or a DC-to-DC charger fed off the bank the alternator charges.
The manual’s words, page 40: “The 2 most popular ways are: AC/DC multi-bank charger such as the NOCO GEN5X2 (available in our online store). ... Using a DC-DC Isolated Charger such as the Victron Orion-Tr DC-DC Converters Isolated.”
The “other parts” line in the estimate above is the priced parts below, $8 to $12 at Fisheries Supply’s prices on 30 September 2026. The batteries, cable and charger have a line of their own.
| Part | What it is | What to ask for | Dealer price |
|---|---|---|---|
| Control-circuit fuse and switch | A small fuse, and often a switch, on the thin wire that powers the panel or control box. | Sideshift names none | $8–$12Blue Sea in-line ATO fuse holders, at Fisheries Supply, read 16 October 2026. |
| Battery cable and lugs | The two heavy cables from the battery to the motor, sized to the length of the run. The wiring calculator sizes them. | 1/0 AWG (230 series) or 2/0 AWG tinned battery cable | In the electrical line |
| Battery bank | A cranking-type bank near the motor, sized by the maker's cold cranking amps. The battery calculator checks it. | Sideshift names none | In the electrical line |
| Charger or charge feed | How the thruster bank gets charged: a shore charger of its own, a DC-to-DC charger or charging relay from the boat's system, or a charger built into the unit. | NOCO GEN5X2, or a Victron Orion-Tr Smart isolated DC-DC charger | $146–$305NOCO GEN5X2 shore charger, Victron Orion-Tr Smart DC-DC charger, Blue Sea ML-ACR charging relay, at Fisheries Supply. |
The cost page has the whole list with what every maker says about each part.
For the yard and the installer
The full spec sheet, grouped the way a yard reads it. Every figure is the maker’s or a dealer’s, with its source.
| Thrust and motor | |
|---|---|
| Thrust | Not published |
| Motor | 3.73 kW |
| Voltage | 12 V |
| Fitting | |
| Type | External, fixed mount |
| End of the boat | Stern |
| What it does to the hull | Three small holes, all above the waterline |
| Haul-out to fit it | No: the maker says it goes on afloat |
| Drive | Mounts on a sterndrive only. |
| Maker’s boat length | 30 to 40 ft |
| Price and ordering | |
| Price | $4,995 full kit, the maker's own price, sideshift.com, 28 August 2026 |
| Part number | Not held for this listing |
| Documents | |
| Manual | Installation manual (PDF)on the maker's site |
| Warranty | Sideshift gives 2 years against faulty workmanship or materials. Its exclusions include wrong wire size or low voltage, burn-out from overuse, collisions, and tangled line or netting. installation manual, Rev 3.1, p. 68 |
| The site’s review | Sideshift thruster review |
Draw, cable, fuse and battery, at each voltage
These are the maker’s own figures, at each voltage it is sold at. The cable is the size for the shortest run in the maker’s table. A longer run may need heavier cable, and the wiring calculator works that out for your own boat.
| Voltage | Draw | Maker’s cable | Fuse | Battery | Run limit |
|---|---|---|---|---|---|
| 12 V | 500 Astart current | 2/0 AWG. The manual keeps the run to 10 ft of cable counted out and back. The FAQ allows the battery up to 30 ft from the controllerinstallation manual, Rev 3.1 | Not published | 850 CCA minimum, as one 12 V starting battery per thruster; this kit has two motors, and the manual's table is per thrusterSideshift installation manual, Rev 3.1, p.39, and the FAQ | bursts of 3 to 5 seconds, never more than 20 to 30 seconds at a timeinstallation manual, Rev 3.1 |
- At 12 V: size the cable for your run, or check the battery you have.
What holds up and what to weigh
Each point names the fact it rests on.
What holds up
- It goes on with the boat in the water. No haul-out is needed to fit it.Sideshift: "All Sideshift thrusters can be installed in-water since all the mounting locations and cable connections are routed above the waterline."
What to weigh
- Sideshift publishes no thrust figure for it. The boat table uses our estimate from the motor's rating.The maker's published specs
- It runs in bursts of 3 to 5 seconds, never more than 20 to 30 seconds at a time.installation manual, Rev 3.1
What the manual and listings say
This is the note we keep on the Sideshift SD230-D Sterndrive Stern Thruster, written from the maker’s manual, its product pages and the dealer’s listing.
In the box: Two thrusters in the kit, one for each end. The kit has the thruster, the controller, the wireless joystick and key fob, the harness, the fuse and a battery switch. You buy the batteries, the cable and a charger. The joystick is wireless but needs 12 V at the helm for its own power.
Our note
Two SD230 units, one bolted to the cavitation plate of each sterndrive, on one controller and one joystick. Nothing goes through the hull, and it goes on afloat. Its product page says 550 A. The manual says 500. It runs on two 12 V starting batteries in parallel (1,700 cold cranking amps) on 2/0 AWG cable, up to 40 ft from the controller.
At planing speed the manual has you trim the drive so the thruster rides just above the surface. Trimmed wrong, it steers heavy and can damage the unit. Each unit pushes on its drive behind the point the drive steers on, so it can try to turn the drive and the wheel with it. Keep a hand on the wheel while you use it.
Bursts only: the manual asks for pushes of 3 to 5 seconds as normal practice, and never more than 20 to 30 seconds at a time. Its warranty does not cover a motor burned out by overuse. On 17 September 2026 sideshift.com was running an end of summer sale, with ten percent off every thruster. The price here is the list price. The sale was still on when the page was read again on 2 October 2026.
Videos
Two of Sideshift’s own videos, from its YouTube channel: an outboard or sterndrive stern kit going on, then the boat on the water, and the whole install, in four minutes. They are the maker’s pitch. Watch them for what the unit looks like and how it goes in, and take any claim back to the figures above.
Other sizes and close alternatives
These are Sideshift’s nearest sizes by thrust, in any of its lines.
- One size down: Sideshift SD240 Sterndrive Stern Thruster, no published thrust, $4,995.
- One size up: Sideshift SD240-D Sterndrive Stern Thruster, no published thrust, $5,495.
Sideshift prints no thrust, so we name no other maker’s unit as its match. The compare page lists every model.
Every model with a page here is listed, maker by maker, on the thruster index.